use of waste tile as a replacement of aggregate

mangalore tile waste as coarse aggregate in .

mangalore tile waste as coarse aggregate in concrete. The use of recycled aggregates from construction and demolition wastes is showing presents the experimental results of recycled coarse aggregate concrete and . in construction of low rise buildings, concrete paving blocks & tiles, flooring,

Get Price

PROPERTIES OF CONCRETE WITH CRUSHED WASTE CERAMIC TILES .

waste wall and floor tiles as a replacement for natural coarse aggregate. The waste tile aggregate was crushed and graded to have the same size of natural coarse aggregate. The study was done by replacing 0%, 50% and of natural coarse aggregate with waste tile aggregates. The reduction in strength of concrete due to the

Get Price

Ceramic Waste : Effective Replacement Of Cement For ...

to find a use of ceramic waste produced. Ceramic waste can be used in concrete to improve its strength and other durability factors. Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary .

Get Price

A REVIEW PAPER ON UTILISATION OF CERAMIC WASTE IN .

concrete utilizing waste materials viz: ceramic tiles, ceramic insulator waste and broken glass pieces. Ceramic tiles gave the best results when compared to the other two type of waste. The concrete produced by ceramic tile aggregate produced similar strength in compression, split tensile and flexure as conventional concrete.

Get Price

Utilization Of Waste Ceramic Tiles As Coarse Aggregate In ...

This chapter establishes the need of use of tile aggregate as a partial replacement of natural aggregates in concrete in order to achieve sustainable development. II. AGGREGATE DEMAND The global market for construction aggregates has increased 5.2 percent per year through 2015 to .

Get Price

CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL ...

aggregates replacement towards compressive strength of concrete. iii) To determine the water absorption of ceramic aggregate concrete containing various content of ceramic tile as partial coarse aggregates replacement material. 1.4 SCOPE OF STUDY Ceramic tile waste use in this research was taken from old site factory The

Get Price

Replacement of Coarse and Fine Aggregate by .

Corpus ID: 172133295. Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete @inproceedings{Magesh2018ReplacementOC, title={Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete}, author={B. Magesh}, year={2018} }

Get Price

use of waste tile waste as partial replacement of ...

Effect of Crushed Waste Ceramic Tiles (CWCT) as . 2018-3-31 · In their study, ceramic tile waste was used in the concrete as a replacement for natural coarse aggregate with (0%, 10%, 20%, and 30%) of the substitution and M20 grade concrete were used.

Get Price

A Review on use of Ceramic waste as coarse Aggregate ...

DOI : 10.23883/IJRTER.2019.5065.BL4X5 37 A Review on use of Ceramic waste as coarse Aggregate Replacement in Concrete Akash Gaikwad 1,Col. B K Bhonde 2 1 PG Student, Department of civil Engineering, Dr. Dy Patil college of Engineering Akurdi Pune 2Assistant Professor Department of civil Engineering, Dr. Dy Patil college of Engineering Akurdi Pune

Get Price

Use of Waste Ceramic Tile Aggregates as an .

Use of Waste Ceramic Tile Aggregates as an Alternative Material of Coarse Aggregates in Cement Concrete - written by Jaspreet Singh, Amanpreet Singh Virk, Gurpreet Singh Bath published on 2018/04/24 download full article with reference data and citations

Get Price

Replacement of Coarse and Fine Aggregate by .

Corpus ID: 172133295. Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete @inproceedings{Magesh2018ReplacementOC, title={Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete}, author={B. Magesh}, year={2018} }

Get Price

Replacement of Coarse and Fine Aggregate by .

Corpus ID: 172133295. Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete @inproceedings{Magesh2018ReplacementOC, title={Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete}, author={B. Magesh}, year={2018} }

Get Price

A Review on use of Ceramic waste as coarse Aggregate ...

DOI : 10.23883/IJRTER.2019.5065.BL4X5 37 A Review on use of Ceramic waste as coarse Aggregate Replacement in Concrete Akash Gaikwad 1,Col. B K Bhonde 2 1 PG Student, Department of civil Engineering, Dr. Dy Patil college of Engineering Akurdi Pune 2Assistant Professor Department of civil Engineering, Dr. Dy Patil college of Engineering Akurdi Pune

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF WASTE .

If we use waste and broken tiles as coarse aggregates in concrete manufacturing. Ceramic tiles can be used as coarse aggregate since they are angular in nature and can be used in similar size of coarse aggregate. This replacement has a huge saving of energy and also has an environmental benefits. Besides, it will also

Get Price

Ceramic Waste : Effective Replacement Of Cement For ...

to find a use of ceramic waste produced. Ceramic waste can be used in concrete to improve its strength and other durability factors. Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary .

Get Price

IOP Conference Series: Materials Science and Engineering ...

ratio of coarse aggregate is 50%. Awoyera et al. [9] used ceramic tile waste as coarse aggregate in concrete.Theresultsshowed that theincrease in strength isabout 36.1% correspondingtoareplacement ratio of . Kavitha and Sundar [10] carried out experimental study to use ceramic tile waste as partial replacement of coarse aggregate in concrete.

Get Price

Use of copper slag as a replacement for fine aggregate in ...

cement replacement in concrete, fill, ballast, abrasive, aggregate, glass, tiles etc (Shi and Meyer [4]). Shoya et al [5] found no major differences in concrete compressive strength due the use of cooper slag as a replacement for fine aggregate. Resende et al. [6] reported a small reduction in concrete compressive and flexural strengths due to

Get Price

The Utilization of Recycled Masonry Aggregate and .

14-06-2019· 2.1. Recycled Aggregate. This research used one type of NA, two types of RMA, and one type of recycled EPS. Both types of RMA originated from construction and demolition waste and were delivered in fractions of 0–8 and 8–16 mm by a Czech recycling center (see Figure 1).For utilization as a substitute for fine-grained aggregate, in mixtures with an aggregate of fraction 0–16 mm in various ...

Get Price

Using Crushed Tiles as Coarse Aggregate in Concrete Mix

pollution. The amount of tile waste on earth is enough for use as an aggregate in concrete. Tile is produced from natural materials sintered at high temperatures. Some parts of tiles are used as flooring and also flooring in tennis courts, walkways, cycling paths and gardens as a ground material. Waste tiles are stored in factory fields because ...

Get Price

Utilization Of Waste Ceramic Tiles As Coarse Aggregate In ...

This chapter establishes the need of use of tile aggregate as a partial replacement of natural aggregates in concrete in order to achieve sustainable development. II. AGGREGATE DEMAND The global market for construction aggregates has increased 5.2 percent per year through 2015 to .

Get Price

mangalore tile waste as coarse aggregate in .

mangalore tile waste as coarse aggregate in concrete. The use of recycled aggregates from construction and demolition wastes is showing presents the experimental results of recycled coarse aggregate concrete and . in construction of low rise buildings, concrete paving blocks & tiles, flooring,

Get Price

Replacement of Coarse and Fine Aggregate by .

Corpus ID: 172133295. Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete @inproceedings{Magesh2018ReplacementOC, title={Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete}, author={B. Magesh}, year={2018} }

Get Price

Partial Replacement of Aggregates with Ceramic Tiles and ...

15-11-2016· building. The waste tiles were crushed into small pieces by manually and by using crusher. The required size of crushed tile aggregate was separated to use them as partial replacement to the natural coarse aggregate. The tile waste which is lesser than 4.75 mm size was neglected. The crushed tile aggregate passing through 16.5mm sieve and ...

Get Price

(PDF) USE OF ELECTRONIC WASTE AS A PARTIAL .

Electronic waste or e-waste describes discarded electrical or electronic devices. Used electronics which are destined for reuse, resale, salvage, recycling or disposal are also considered as e-waste. Informal processing of electronic waste in

Get Price

VALLUR,PRAKASAM(Dt).

Crushed waste ceramic tiles, crushed waste ceramic tile powder and Granite powder are used as a replacement to the coarse aggregates and fine aggregate. The ceramicwaste crushed tiles were partially replaced in place of coarse aggregates by 10%, 20%, 30%, 40% and 50%.Granite powder and ceramic tile powder were

Get Price

Use of Waste Ceramic Tile Aggregates as an .

Use of Waste Ceramic Tile Aggregates as an Alternative Material of Coarse Aggregates in Cement Concrete - written by Jaspreet Singh, Amanpreet Singh Virk, Gurpreet Singh Bath published on 2018/04/24 download full article with reference data and citations

Get Price

Partial Replacement of Coarse Aggregate with Demolished ...

of recycled concrete up to 30% coarse aggregate replacement (C. A. R.) by demolished waste at the end of 28 d has been found to be comparable to the conventional concrete. 3. "Use of Building Demolished Waste as Course Aggregate in Use of recycled aggregate in concrete can be useful for Porous Concrete" IJRET: International

Get Price

use of waste tile as a replacement of aggregate

replacement of cement with fly ash and fine aggregate with foundry sand The principle point of this exploration is to ponder the use of waste ceramic tiles as a fractional replacement of coarse aggregate (20mm) and 10% fly fiery remains as a supplanted of cement in concrete For every one of

Get Price

Effect of Partial Replacement of Fine and Coarse Aggregate ...

replacement of sand or partial replacement of coarse aggregate but in this research both the components has been used parallel at equal percentage. Ceramic Waste . The amount of ceramic tile waste on earth is enough for use as a coarse and fine aggregate in concrete. Ceramic tile is produced from natural materials sintered at high temperatures ...

Get Price

AN EXPERIMENTAL WORK ON CRUSHED CERAMIC WASTE TILES .

Effect of Waste Ceramic Tiles in Partial Replacement of Coarse and Fine Aggregate of Concrete, Vol. 2, Issue 6, June 2015 4)E. E. Ikponmwosa1,* and S. O. Ehikhuenmen2, the effect of ceramic waste as coarse aggregate on strength properties of concrete,Vol. 36, No. 3, July 2017 5) N.Naveen, Prasad1, P.Hanitha2, N.C.Anil, Dec. (2016), Partial ...

Get Price